Analysis Factors Of Liquid Waste Treatment OnLiquid Waste Processing UnitSugar Industrial (Case Study PGXYZ)
Keywords:
liquid waste, sugar industry, IPALAbstract
The Liquid waste sugar industry can cause pollution in the waters due to contamination, deoxygenationby pollutants and strong odors caused by biodegradation of waste in the form of hydrogen sulfide gas. Liquid sugar industry wastes can increase the levels of BOD (Biological Oxygen Demand), COD (Chemical Oxygen Demand), and TSS (Total Suspended Solid) in the waters so that handling of these wastes is needed. The purpose of this study is to determine the factors that influence each stage of the waste treatment process so that wastewater treatment can run effectively and efficiently. The results showed that the factors that could influence the purification of liquid waste were pH, temperature, discharge of wastewater, and active sludge content. The pH value of inlet of wastewater that can be tolerated is between 7-9 with a maximum temperature of 40ºC with a debitt of wastewater in the aeration pond a maximum of 120 m3 / hour and a condition of active sludge volume of 30-40%..
References
Agustinus, E. T. S., Sembiring, H., & Effendi, E. (2014). Implementasi Material Preservasi Mikroorganisme (Mpmo) Dalam Pemrosesan Limbah Cair Organik Pada Instalasi Pengolahan Air Limbah. RISET Geologi Dan Pertambangan, 24(1), 65–76.Atima, W. (2015). BOD dan COD sebagai parameter pencemaran air dan baku mutu air limbah. Biosel (Biology Science andEducation): Jurnal Penelitian Sains Dan Pendidikan, 4(1), 83–93.Batara, K., Zaman, B., & Oktiawan, W. (2017). Pengaruh Debit Udara dan Waktu Aerasi Tehadap Efisiensi Penurunan Besi dan Mangan Menggunakan Diffuser Aerator pada Air Tanah. Diponegoro University. Danil, R., Kirom, M. R., & Qurtobi, A. (2017). Analisis Pengaruh Suhu Dan Ph Terhadap Penurunan Kadar Chemical Oxygen Demand Dalam Sistem Temperature Phased Anaerobic Digestion Dengan Substrat Limbah Makanan. EProceedings of Engineering, 4(2).Fitri,H. M., Hadiwidodo, M., & Kholiq, M. A. (n.d.). Penurunan Kadar Cod, Bod, Dan Tss Pada Limbah Cair Industri MSG (Monosodium Glutamat) Dengan Biofilter Anaerob Media Bio-ball. Diponegoro University.Hasanudin, U., & Suroso, E. (2013). Kajian Efektifitas Penggunaan Tanaman Eceng Gondok (Eichornia crassipes) Dalam Menurunkan Beban Pencemar Air Limbah Industri Gula Tebu. Jurnal Teknologi & Industri Hasil Pertanian, 18(2), 157–167.Isyuniarto, I., & Andrianto, A. (2009). Pengaruh Waktu Ozonisasi Terhadap Penurunan Kadar Bod, Cod, Tss Dan Fosfat Pada Limbah Cair Rumah Sakit. GANENDRA Majalah IPTEK Nuklir, 12(1).Marlina, N., Hudori, H., & Hafidh, R. (2017). Pengaruh Kekasaran Saluran dan Suhu Air Sungai pada Parameter Kualitas Air COD, TSS di Sungai Winongo Menggunakan Software QUAL2Kw. Jurnal Sains & Teknologi Lingkungan, 9(2), 122–133.Ningtyas, R. (2015). Pengolahan Air Limbah dengan Proses Lumpur Aktif. Jurusan Teknik Kimia, Institut Teknologi Bandung, Indonesia.Oktavia, L. (2012). Pengolahan Limbah Cair Pabrik Gula Menggunakan Kolam Aerasi Dengan Penambahan Inola-121. Jurnal Purifikasi, 13(1), 9–16.Ratnani, R. D. (2012). Kecepatan Penyerapan Zat Organik Pada Limbah Cair Industri Tahu Dengan Lumpur Aktif. Jurnal Ilmiah Momentum, 7(2).Said, N. I., &Utomo, K. (2007). Pengolahan Air Limbah Domestik Dengan Proses Lumpur Aktif Yang Diisi Dengan Media Bioball. Jurnal Air Indonesia, 3(2).Said, N. I. 2002. Teknologi Pengolahan Limbah Cair Industri. PusatPengkajian dan Penerapan Teknologi Lingkungan. ISBN: 979-8465-38-5.
Downloads
Submitted
Published
How to Cite
Issue
Section
License
Copyright (c) 2020 The Author (s)
This work is licensed under a Creative Commons Attribution-NonCommercial-ShareAlike 4.0 International License.
The author whose published manuscript approved the following provisions:
1. The right of publication of all material published in the journal / published in the Agroindustrial Technology Journal is held by the editorial board with the knowledge of the author (moral rights remain the author of the script).
2. The formal legal provisions for access to digital articles of this electronic journal are subject to the terms of the Creative Commons Attribution-NonCommercial-ShareAlike 4.0 International License (CC BY-NC-SA 4.0), which means that Agroindustrial Technology Journal reserves the right to save, transmit media or format, Database), maintain, and publish articles without requesting permission from the Author as long as it keeps the Author's name as the owner of Copyright.
3. Printed and electronically published manuscripts are open access for educational, research and library purposes. In addition to these objectives, the editorial board shall not be liable for violations of copyright law.
