Application of tofuwaste bioactivation in making organic liquid fertilizer from market waste and dry leaves
Keywords:
Organic fertilizers, tofu wastewater, fermentation, solid bioactivator, EM4Abstract
Organic fertilizers contain a lot of residual organic matter that has been decomposed and is ready for consumption by plants. The raw materials for organic liquid fertilizer used in this study were market waste, dry leaves, and the addition of three bio activators (tofu wastewater, Stardec, and EM4). The selection of tofu liquid waste is done because it is easy to obtain, cheap, and reduces environmental pollution. Therefore, the purpose of this study was to analyze the quality and quality of the manufacture of liquid fertilizer using the tofu industry's liquid waste bio activator compared to other bio activators. The method used in this research is the experimental manufacture of liquid fertilizer with anaerobic fermentation, which is then applied to the growth of kale. The results of this study are the quality and quality of the manufacture of liquid fertilizer using a liquid waste bio activator tofu industry is quite good, although it still does not meet the minimum Technical Requirements for Organic Fertilizer standards issued by the Decree of the Minister of Agriculture of the Republic of Indonesia Number 261/KPTS/SR.310/M /4/2019. This can be seen from the average height of the kale plant which is not much different from the use of popular bio activators on the market (EM4 and Stardec), where the average height yield is 6.72 cm on the seventh day
References
Arquero, O., Barranco, D., Benlloch, M., 2006. Potassium starvation increases stomatal conductance in olive trees. American Society for Horticultural Science 41, 433–436. https://doi.org/10.21273/HORTSCI.41.2.433. Boonrod, K., Towprayoon, S., Bonnet, S., & Tripetchkul, S. (2015). Enhancing organic waste separation at the source behavior: A case study of the application of motivation mechanisms in communities in Thailand. Resources, Conservationand Recycling, 95. https://doi.org/10.1016/j.resconrec.2014.12.002 Campbell, N. A. dan J.B. Reece. 2008. Biologi edisi kedelapan Jilid 2. Erlangga. Jakarta. Ellen Macarthur Foundation. (2014). Towards the Circular Economy: Accelerating the scale-up across global supply chains. https://www.ellenmacarthurfoundation.org/publications/towards-the-circular-economy-vol-3-accelerating-the-scale-up-across-global-supply-chains. (Accessed 14 September 2021).Fernandez-Escobar, R., Ortiz-Urquiza, A., Prado, M., Rapoport, H.F., 2008. Nitrogen status influence on olive tree flower quality and olive longevity. Environmental and Experi-mental Botany 64, 113–119. https://doi.org/10.1016/j.envexpbot.2008.04.007. Fitriyah, N. R. (2011). Studi Pemanfaatan Limbah Cair Tahu untuk Pupuk Cair Tanaman (Studi Kasus Pabrik Tahu Kenjeran). Surabaya: Teknik Lingkungan.Fitriyah, N. R. (2011). Studi Pemanfaatan Limbah Cair Tahu untuk Pupuk Cair Tanaman (Studi Kasus Pabrik Tahu Kenjeran). Surabaya: Teknik Lingkungan.Hai, D.M., Qiu, X., Xu, H., Honda, M., Yabe, M., Kadokami, K., Shimasaki, Y., Oshima, Y., 2017. Contaminants in liquid organic fertilizers used for agriculture in Japan. Bull. En-viron. Contam. Toxicol. 99 (1), 131–137. https://doi.org/10.1007/s00128-017-2081-y. Havlin, J.L., Tisdale, S.L., Nelson, W.L., Beaton, J.D., 2014. Soil Fertility and Fertilizers, an Introduction to NutrientManagement, 8th edition Pearson, Boston, USA. Karioti, A., Chatzopoulou, A., Bilia, A.R., Liakopoulos, G., Stavrianakou, S., Skaltsa, H., 2006. Novel secoiridoid glucosides in Olea europaea leaves suffering from boron deficiency. Bioscience, Biotechnology, and Biochemistry 70 (8), 1898–1903. https://doi.org/10.1271/bbb.60059. , A., Wojciechowska, R., 2010. The effect of cultivar type, time of cultivation, and biostimulant treatment on the yield of spinach (Spinacia oleracea L.). Folia Horticulturae 22, 9–13. https://doi.org/10.2478/fhort-2013-0153. Liao, H., Friman, V.P., Geisen, S., Zhao, Q., Cui, P., Lu, X., Chen, Z., Yu, Z., Zhou, S., 2019. Horizontal gene transfer and shifts in linked bacterial community composition are associated with maintenance of antibiotic resistance genes during food waste composting. Sci. Total Environ. 660, 841–850. https://doi.org/10.1016/j. scitotenv.2018.12.353. Ma, Y.Q., Yin, Y., Liu, Y., 2017a. A holistic approach for food waste management towards zero-solid disposal and energy/resource recovery. Bioresour. Technol. 228, 56–61. https://doi.org/10.1016/j.biortech.2016.12.090. Ma, Y.Q., Yin, Y., Liu, Y., 2017b. New insights into co-digestion of activated sludge and food waste: biogas versus biofertilizer. Bioresour. Technol. 241, 448–453. https://doi.org/ 10.1016/j.biortech.2017.05.154. McNicol, G., Jeliazovski, J., Fran, J. J., Kramer, S., & Ryals, R. (2020). Climate change mitigation potential in sanitation via off-site composting of human waste. Nature Climate Change, 10. https://doi.org/10.1038/s41558-020-0782-4 Mengel, K., 2002. Alternative or complementary role of foliar supply in mineralnutrition. Acta Horticulturae 594, 33–47. https://doi.org/10.17660/ActaHortic.2002.594.1. Mostafazadeh-Fard, S., Samani, Z., Bandini, P., 2017. Production of liquid organic fertilizer through anaerobic digestion of grass clippings. Waste Biomass Valor. 10 (4), 771–781. https://doi.org/10.1007/s12649-017-0095-7. Mulyani, S. 1994. Pupuk dan Cara Pemupukan. Rineka Cipta. Jakarta. Nakasaki, K., Hirai, H., Mimoto, H., Quyen, T.N.M., Koyama, M., Takeda, K., 2019. Succes-sion of microbial community during vigorous organic matter degradation in the pri-mary fermentation stage of food waste composting. Sci. Total Environ. 671, 1237–1244. https://doi.org/10.1016/j.scitotenv.2019.03.341. Naschitz, S., Naor, A., Genish, S., Wolf, S., Goldschmidt, E.E., 2010. Internal management of non-structural carbohydrate resources in apple leaves and branch wood under a broad range of sink and source manipulations. Tree Physiology 30, 715–727. https://doi.org/10.1093/treephys/tpq028. Niu, Y., Zheng, D., Yao, B.H., Cai, Z.Z., Zhao, Z.M., Wu, S.Q., Cong, P.Q., Yang, D.P., 2017. A novel bioconversion for value-added products from food waste using Musca domestica. Waste Manag. 61, 455–460. https://doi.org/10.1016/j.wasman.2016.10.054. Oteng-Ababio, M., Melara Arguello, J. E., & Gabbay, O. (2013). Solid waste management in African cities: Sorting the facts from the fads in Accra, Ghana. Habitat International, 39. https://doi.org/10.1016/j.habitatint.2012.10.010Pancapalaga, W. 2011. Pengaruh Rasio Penggunaan Limbah Ternak dan Hijauan terhadap Kualitas Pupuk Cair. Gamma 7(1), Hal 61-68. Paul, S., Dutta, A., Defersha, F., Dubey, B., 2017. Municipal food waste to biomethane and biofertilizer: a circular economy concept. Waste Biomass Valori. 9 (4), 601–611. https://doi.org/10.1007/s12649-017-0014-y. Peraturan Menteri Pertanian Nomor: 2/Pert./HK.060/2/2006Tentang Pupuk Organik dan Pembenah Tanah.Saadati, S., Moallemi, N., Mortazavi, S.M.H., Seyyednejad, S.M., 2013. Effects of zinc and boron foliar application on soluble carbohydrate and oil contents of three olive cultivars during fruit ripening. Scientia Horticulturae 164, 30–34.Schmitz-Eiberger, M., Haefs, R., Noga, G., 2002. Calcium deficiency -Influence on the antioxidative defense system in tomato plants. Journal of Plant Physiology159, 733–742. https://doi.org/10.1078/0176-1617-0621.Simamora, S., dan Salundik. (2005). Meningkatkan Kualitas Kompos. Agromedia Pustaka. JakartaSungguh A. 1993. Kamus Lengkap Biologi. Gaya Media Pratama. Jakarta.Sutanto, Rachman. 2002. Penerapan Pertanian Organik : Pemasyarakatan & Penerapannya. Karisius. Yogyakarta Tekaya, M., El Gharbi, S., Mechri, B., Chehab, H., Bechir, A., Cheraief, I., Ayachi, M., Boujneh, D., Attia, F., Hammami, M., 2016. Improving performance of olive trees by the enhancement of key physiological parameters of olive leaves in response to foliar fertilization. Acta Physiologiae Plantarum 38, 101. https://doi.org/10.1007/ s11738-016-2122-x. Wiesman, Z., Lavee, S., 1995. Relationship of carbohydrate sources and indole-3-butyric acid in olive cuttings. Plant Physiol 22, 811–816. https://doi.org/10.1071/ PP9950811. Winata, L. 1998. Budidaya Anggrek. Penebar Swadaya . Jakarta. Yulipriyanto, H. 2010. Biologi tanah dan startegi pengolahannya. Graha Ilmu. Yogyakarta.
Downloads
Submitted
Published
How to Cite
Issue
Section
License
Copyright (c) 2021 The Author (s)
This work is licensed under a Creative Commons Attribution-NonCommercial-ShareAlike 4.0 International License.
The author whose published manuscript approved the following provisions:
1. The right of publication of all material published in the journal / published in the Agroindustrial Technology Journal is held by the editorial board with the knowledge of the author (moral rights remain the author of the script).
2. The formal legal provisions for access to digital articles of this electronic journal are subject to the terms of the Creative Commons Attribution-NonCommercial-ShareAlike 4.0 International License (CC BY-NC-SA 4.0), which means that Agroindustrial Technology Journal reserves the right to save, transmit media or format, Database), maintain, and publish articles without requesting permission from the Author as long as it keeps the Author's name as the owner of Copyright.
3. Printed and electronically published manuscripts are open access for educational, research and library purposes. In addition to these objectives, the editorial board shall not be liable for violations of copyright law.
